BURKERT（寶德）電磁閥，BURKERT

分步直動式BURKERT電磁閥 　　BURKERT電磁閥采用次開閥和二次開閥連在體，主閥和導閥分步使電磁力和壓差直接開啟主閥口。當線圈通電時，產生電磁力使動鐵芯和靜鐵芯吸合，導閥口開啟而導閥口設在主閥口上，且動鐵芯與主閥芯連在起，此時主閥上腔的壓力通過導閥口卸荷，在壓力差和電磁力的同時作用下使主閥芯向上運動，開啟主閥介質流通。當線圈斷電時電磁力消失，此時動鐵芯在自重和彈簧力的作用下關閉導閥孔，此時介質在平衡孔中進入主閥芯上腔，使上腔壓力升高，此時在彈簧復位和壓力的作用下關閉主閥，介質斷流。結構合理，動作可靠，在零壓差時工作也可靠。如：ZQDF，ZS，2W等。 　　三、間接導式BURKERT電磁閥 　　該系列BURKERT電磁閥由導閥和主閥芯著形成通道組合而成；常閉型在未通電時，呈關閉狀態。當線圈通電時，產生的磁力使動鐵芯和靜鐵芯吸合，導閥口打開，介質流向出口，此時主閥芯上腔壓力減少，低于進口側的壓力，形成壓差克服彈簧阻力而隨之向上運動，達到開啟主閥口的目的，介質流通。當線圈斷電時，磁力消失，動鐵芯在彈簧力作用下復位關閉導口，此時介質從平衡孔流入，主閥芯上腔壓力增大，并在彈簧力的作用下向下運動，關閉主閥口。常開式原理正好相反。如：SLA，DF（φ15以上口徑），ZCZ等。

BURKERT（寶德）電磁閥，BURKERT
BURKERT電磁閥的4大特性
適用 　　管路中的流體必須和選用的BURKERT電磁閥系列型號中標定的介質*。 　　流體的溫度必須小于選用BURKERT電磁閥的標定溫度。 　　BURKERT電磁閥允許液體粘度般在20CST以下，大于20CST應注明。 　　工作壓差，管路zui高壓差在小于0.04MPa時應選用如ZS,2W,ZQDF,ZCM系列等直動式和分步直動式；zui低工作壓差大于0.04MPa時可選用導式（壓差式）BURKERT電磁閥；zui高工作壓差應小于BURKERT電磁閥的zui大標定壓力；般BURKERT電磁閥都是單向工作，因此要注意是否有反壓差，如有安裝止回閥。 　　流體清潔度不高時應在BURKERT電磁閥前安裝過濾器，般BURKERT電磁閥對介質要求清潔度要好。 　　注意流量孔徑和接管口徑；BURKERT電磁閥般只有開關兩位控制；條件允許請安裝旁路管，便于維修；有水錘現象時要定制BURKERT電磁閥的開閉時間調節。 　　注意環境溫度對BURKERT電磁閥的影響 　　電源電流和消耗功率應根據輸出容量選取，電源電壓般允許±10%左右，必須注意交流起動時VA值較高。 　　2、可靠性 　　BURKERT電磁閥分為常閉和常開二種；般選用常閉型，通電打開，斷電關閉；但在開啟時間很長關閉時很短時要選用常開型了。 　　壽命試驗，價格般屬于型式試驗項目，確切地說我國還沒有BURKERT電磁閥的標準，因此選用BURKERT電磁閥價格時慎重。 　　動作時間很短頻率較高時般選取直動式，大口徑選用快速系列。 　　3、安全性 　　般BURKERT電磁閥不防水，在條件不允許時請選用防水型，價格可以定做。 　　BURKERT電磁閥的zui高標定公稱壓力定要超過管路內的zui高壓力，否則使用壽命會縮短或產生其它意外情況。 　　有腐蝕性液體的應選用全不銹鋼型，強腐蝕性流體宜選用塑料王（SLF）BURKERT電磁閥。 　　爆炸性環境必須選用相應的防爆產品。 　　4、經濟性 　　有很多BURKERT電磁閥可以通用，但在能滿足以上三點的基礎上應選用的產品。